Cheesepalooza Challenge 9 – Brie Part 1

March slipped away and we were not able to do Cheesepalooza Challenge 8 – Gruyere or Jarlsberg (we will make these soon!) but we are back in the game for challenge 9 Brie or Camembert. Now I have to admit, neither Brie nor Camembert are a favourite of our family, but Brie is a favourite of J’s Aunt, so Brie it is!

We used the recipe for American Style Brie from Mary Karlin’s Artisan Cheese Making. We used 8 l of Vital Greens un homogenized whole milk and 1/2 c of their delicious 52% heavy cream.

As with our progression through cheesepalooza there is always a new twist or technique to advance our skills. The new twist for this recipe is we get to use penicillium candidum and geotrichum candidum! Mold!

20130429-212258.jpg
We brought the milk and cream up to 90 degrees F, this time using the good old sink water bath (I must admit we did cheat a bit with the pot on the stove for a bit, then finished in the water bath). After at temperature the MA 4001 and Thermo B Starter cultures, and the two mold powders were added and left to rehydrate.

20130429-213100.jpgThese were then stirred in and left to rest for 1.5 hours.

The calcium chloride and rennet were then added and left to rest for 30 minutes. Now this break was not clean, but close so I did cut the curd.

20130429-213531.jpgThe curds were left to rest for a bit then stirred for 15 minutes. They really seemed to break down, so amateur cheese maker panic started to set in, but at this point all you can do is push on and hope it is just uncertainty of charting new territory, if not it is a learning experience!

20130429-214032.jpgAfter the rest the whey was removed to expose the curds. And then the curds scooped out and placed in the moulds. I started with two 4 inch bottomless moulds, but had extra curd so brought out two 3 inch crottin moulds.

20130429-214655.jpgThe cheese is now flipped every hour about 5 times until there is very little whey draining. While getting the cheeses settled in the ripening box I had a small issue.

20130429-215231.jpgBut I managed to get it back in the mould.

Now time for the first flip!

20130429-215653.jpgAnd after the first flip! The draining matt pattern is sure cool!

20130429-215706.jpg

20130429-220007.jpgAfter the 4 th flip it seemed like a good photo opportunity!

20130429-220300.jpgThen I reread the recipe, leave in mould over night! So back in the mould it went!

First thing in the morning the cheeses were removed from the moulds. Their weights and height at this time were: 450 g 4.5 cm, 430g 4.25 cm, 198 g 3.25 cm and 174 g 3.0 cm. They were then salted.

20130429-220620.jpg

20130429-220637.jpg

20130429-220644.jpgNow the cheeses begin the blooming phase of ripening. This is when the white mold forms on the surface. It should bloom in 3-4 days, then they are flipped so the other side can bloom for another 1 or 2 days. After this they are wrapped in special cheese paper to ripening for 5-6 weeks.

As of this writing we are only 1/2 a day in. So I will update as we progress.

So far this has been fairly straightforward, monitoring the ripening process will likely be the challenge for this one.

The ripening is going well, very easy. Here it is at about 4 weeks.

20130608-165225.jpg

20130608-165241.jpg

Check out Part 2 for the tasting!

Advertisements

9 thoughts on “Cheesepalooza Challenge 9 – Brie Part 1

  1. ihtreuer

    You are already doing better at this stage than I was. I have a rack that I put my draining bin under, this way I can flip it without having too much spillage. I can’t wait to see the results. Well done.

    Reply
    1. konadaddy Post author

      Thanks! they look good but the real test will be in a few weeks. I wonder how much smaller they will get? they are a bit higher than a traditional Brie.

      I had to improvise on the rack to fit the round container. I used 2 “Dino” sandwich cutters, and place a round stainless rack with holes, followed by the plastic mats. I will look around for a rectangular container, much easier to find a rack to fit.

      Reply
  2. Narissa

    Some beautiful looking cheese there, konadaddy and son! It will be interesting to see (and taste) the finished product after the requisite ripening process. I do love me a round of Brie! 😉

    Reply
  3. Pingback: Cheesepalooza Roundup Challenge Nine: Brie and Camembert

  4. Pingback: Cheesepalooza Challenge 9 – Brie Part 2 | La Bonne Vie

Leave a Reply

Fill in your details below or click an icon to log in:

WordPress.com Logo

You are commenting using your WordPress.com account. Log Out / Change )

Twitter picture

You are commenting using your Twitter account. Log Out / Change )

Facebook photo

You are commenting using your Facebook account. Log Out / Change )

Google+ photo

You are commenting using your Google+ account. Log Out / Change )

Connecting to %s